Stoelting 513588R1 User Manual

OPTIMA 111OWNER'S MANUALManual No. 513588R1 Nov. 2004

2MODEL OPTIMA 111COUNTER MODELGRAVITY FREEZERDIMENSIONS:Freezer: 19-11/16" (50 cm) wide x 31-5/8" (80.3 cm) deep x 37-7/16" (95 cm) hig

3SECTION 2INSTALLATION INSTRUCTIONS2.1 SAFETY PRECAUTIONSDo not attempt to operate the freezer until the safetyprecautions and operating instructions

42.2 SHIPMENT AND TRANSITThe freezer has been assembled, operated and inspectedat the factory. Upon arrival at the final destination, thecomplete free

5Figure 8 - Floor Stand2.5 INSTALLING PERMANENT WIRINGIf permanent wiring is required by local codes, the follow-ing procedure must be performed.WARNI

6

7SECTION 3INITIAL SETUP AND OPERATION3.1 OPERATOR'S SAFETY PRECAUTIONSSAFE OPERATION IS NO ACCIDENT; Observe theserules:A. Know the freezer. Read

8B. OFF-ON SWITCHThe OFF-ON switch is a two position toggle switchused to supply power to the control circuit. When theswitch is in the OFF position,

9CAUTIONPROLONGED CONTACT OF SANITIZER WITHFREEZER MAY CAUSE CORROSION OF STAIN-LESS STEEL PARTS.In general, sanitizing may be conducted as follows:A.

10G. After about 6 to 10 minutes the freezer will shut OFFand the green lens will illuminate. The product is readyto serve. Freeze down time may be lo

113.7 CLEANING THE FREEZERNOTEThe frequency of cleaning the freezer and freezerparts must comply with local health regulations.After the mix has been

123.9 CLEANING THE FREEZER PARTSPlace all loose parts in a pan or container and take to thewash sink for cleaning. To clean freezer parts refer to the

13A. Assemble all "O" Rings onto parts dry, without lubri-cation. Then apply a thin film of sanitary lubrication toexposed surfaces of the &

14CLEANING vs. SANITIZINGIt is important to distinguish between cleaning andsanitizing. Although these terms may soundsynonymous, they are not. BOTH

153. SANITIZING – After the machine has beencleaned and contains no milkstone, themachine is reassembled. Then a FDA-approvedsanitizing solution is r

16D. MONTHLYCAUTIONTHE FREEZER HAS AN AIR COOLED CON-DENSER AND MUST HAVE PROPER AIR CIRCU-LATION. DO NOT PLACE RIGHT SIDE OFFREEZER ANY CLOSER THAN 3

17SECTION 4TROUBLESHOOTING CHARTSMELBORP ESUACELBISSOP YDEMERtonseodrezeerF.nur.ffosirezeerfotrewoP.1.deppirtronwolbfitiucricroesuF.2.)nruttonlliwregu

18.mrifootsitcudorP.reppohniximoN.1gnieberasnoitropllamS.2.emittrohsanidesnepsiderutarepmetycnetsisnoC.3.mrifootsignitteserutarepmetycnetsisnoC.4.erul

19CODE P.T.F. LIGHT FLASHES MEANING01020304050607Sequence of oneSequence of twoSequence of threeSequence of fourSequence of fiveSequence of sixSequenc

20

21SECTION 5REPLACEMENT PARTS5.1 HOW TO ORDER PARTSTo assure receipt of the proper replacement parts, supplyyour dealer or distributor with the followi

Need Parts or Service?We stock the parts you need.Our Technicians are factorytrained and are certified in theStoelting Technicare program.Model No.:

22U174

23Item Stoelting P/N Qty Description1 2177698 1 Door w/pins (Gravity)2 3159696 1 Spigot3 624598 2 O-Ring 5/8 x 7/8 x 1/8 Minn. Rubber4 508135 AsR

24

25Item Stoelting P/N Qty Description1 342008 1 Drier2 458010 1 Indicator, Sight Glass 1/43 763452 1 Valve Solenoid4 231101-SV 1 Capillary Tube & D

26

27Item Stoelting P/N Qty Description1 4177557 1 Frame Weldment2 538363 4 Nut Hex Jam 3/8-16 x 9/16 Stl Zp3 628064 6 Rivet Drive 1/4 Dia. x 1/44 282032

28

29Item Stoelting P/N Qty Description1 4177572 1 Upper Front Panel2 3177574 1 Right Front Corner Member3 3177575 1 Left Front Corner Member4 628009 6 R

30

31Item Stoelting P/N Qty Description1 3177578 1 Left Side Panel2 3177579 1 Right Side Panel3 701002 2 Standoff4 649000-39 2 Screw, Self Tapping #105 3

WARRANTYSOFT SERVE / SHAKE FREEZERS1. Scope:Stoelting, LLC warrants to the first user (the “Buyer”) that the freezer cylinders, hoppers, compressors,

STOELTING, LLC Tele: 920-894-2293502 Hwy 67Kiel, WI 53042-1600 Fax: 920-894-7029OWNER'S MANUALFORMODEL OPTIMA - STOELTING SOFT SERVECOUNTER MODE

SECTION DESCRIPTION PAGE1. INTRODUCTION1.1 Description...

LIST OF ILLUSTRATIONSFIGURE TITLE PAGE1 Model Optima 111 Freezer ......

1SECTION 1DESCRIPTION AND SPECIFICATIONS1.1 DESCRIPTIONThe Stoelting Optima 111 counter freezer is gravity fed.The freezer is equipped with fully auto